Indonesian Aquaculture Journal, 11 .
, 2016, 41-47 Available online at: http://ejournal-balitbang.
id/index.
php/iaj POTENCY AND EFFICACY TEST OF A VACCINE IN ADDITION WITH ADJUVANT AGAINST KOI HERPESVIRUS IN KOI (Cyprinus carpi.
Lili Sholichah*)#.
Munti Yuhana**).
Angela Mariana Lusiastuti***), and Tri Heru Prihadi***) **) Graduate School of Aquaculture Science.
Bogor Agricultural University.
Indonesia Department of Aquaculture.
Faculty of Fisheries and Marine Science.
Bogor Agricultural University.
Indonesia
***)
Research and Development Institute for Freshwater Aquaculture.
Indonesia
ABSTRACT
Koi Herpesvirus (KHV) is a malignant virus infecting the goldfish and koi in all stadia and cause mortality up to 95%.
The purpose of this study was to determine the potency and efficacy of inactivated-vaccine in addition with adjuvant against KHV in koi fish.
The viral propagation was done using a KF-1 cell line in 25 cm2 flask.
The cultured virus was harvested on 12 days post inoculation, and then the harvested virus was inactivated with 0.
1% formalin as inactivated-vaccine.
Three hundred of test fish .
38 A 1.
maintained in 126 L of plastic containers with aeration, and fed with pellets twice a day.
After 14 days of adaptation, the fish were divided into five treatments (A= vaccine.
B= vaccine Complete FreundAos Adjuvant.
C= vaccine Incomplete FreundAos Adjuvant.
K = positive control, and K-= negative contro.
and each treatment has four Vaccine was given by injecting intramuscularly of 0.
1 mL per fish.
All fish were challenged by injecting intramuscularly of 0.
1 mL of KHV virus with concentration of 104.
58 TCID50/mL after 21 days post The results showed that the B treatment had higher (P<0.
values of hematocrit level, lysozyme activity, and titer of antibody compared with positive control.
In addition, the survival of fish in B treatment also had the highest percentages and significantly different compared to other treatments (P<0.
The conclusion of this research was the application of inactivated KHV vaccine in 0.
1% formalin with the addition of Complete FreundAos Adjuvant through the injection dose 0.
1 mL fish-1 in 104.
58 TCID50/mL capable to enhance the immune responses and raised the optimal protection of KHV antibody in koi fish.
KEYWORDS:
inactivated vaccines.
immune responses.
Cyprinus carpio.
KHV
INTRODUCTION
Koi Herpesvirus Disease (KHV/KHVD) is a virus that causes the contagious disease in koi and goldfish (Ilouze et al.
, 2.
KHVD was first reported in Israel and the United States in 1998.
Furthermore, the disease spread to other countries such as Poland.
UK.
Germany, and the Netherlands (Antychowicz et al.
In Asia.
KHVD outbreak was first reported in Indonesia in April 2002 (Melba, 2.
Fish infected with KHV showed pale white and necrosis in the gill filaments.
Other clinical symptoms may include abnormal eye, pale body surface, mucus production, and pale spots on the skin.
KHV outbreaks in some cases showed no clinical symptoms (Lio-Po.
This virus can infect goldfish when the water Correspondence: Graduate School of Aquaculture Science.
Bogor Agricultural University.
Jl.
Lingkar Akademik.
Kampus IPB Dramaga.
Bogor 16680.
Indonesia.
Phone: .
8621210 E-mail: lili.
bihatdepok@gmail.
temperature ranging from 17AC-27AC whereas high virulence occurs at a temperature of 22AC-24AC (Perelberg et al.
, 2.
Deaths caused by KHV may reach 80%-95% (Sunarto et al.
, 2.
Several kinds of vaccines used in fish farming, among others.
whole-cell vaccines, vaccines from cell components, and DNA vaccines.
The viral vaccine is an antigen preparation derived from attenuated or Yasumoto et al.
in Japan developed a formalin-inactivated vaccine KHV by utilizing liposomal membrane applied to the fish feed.
Nakajima et al.
using iridovirus vaccine from GF cell .
runt fi.
on red sea bream (Pagrus majo.
which was formalin inactivated for 12 days at 4AC and obtain 72% of relative percent survival (RPS).
The type of adjuvant used is Complete FreundAos Adjuvant (CFA) and Incomplete FreundAos Adjuvant (IFA).
According to Aucouturier et al.
IFA is a water in oil (W/O) emulsion, which is able to improve and stabilize the Potency and efficacy test of a vaccine in addition with adjuvant .
(Lili Sholicha.
antibody titer.
The purpose of this study was to determine the potency and efficacy of inactivated vaccine against KHV combine with adjuvant which produced from KF-1 cell cultures.
MATERIALS AND METHODS
Procurement Fish and Virus Isolates Three hundred of koi fish (Cyprinus carpi.
used in this study .
verage weight of 10.
38 A 1.
were obtained from a private farm in Sukabumi.
West Java which provides the SPF (Specific Pathogen Fre.
KHV through previous PCR test.
Virus strain was namely BJMN-2, which was a collection of Research Station for Fish Disease Control.
Depok.
Indonesia.
Cell Culture and KHV Virus KF-1 cells were used in this study.
KF-1 cells were grown in T-flasks at 25AC to confluence in LeibovitzAos media (L-15 : Gibc.
supplemented with 20% FBS (Fetal Bovine Serum : Gibc.
The monolayers of KF-1 cells were inoculated with KHV inoculum then supplemented with 2% FBS, respectively.
Infected cells were incubated at 25AC.
Cytopathic effect (CPE) was daily observed under a light microscopy.
The viral cultured was harvested when cytopathic effect (CPE) had reached A 80%.
Supernatant was taken and stored at -80AC until ready to use and mostly used for the measurement of TCID50.
TCID50
Determination of tissue culture infective dose (TCID.
was performed to quantify how much infectious virus was in a vaccine preparation.
TCID50 calculation was based on the method of Reed & Muench .
E 50% A a E
TCID 50 A E
E bAa E Where: a= % positive at dilution below 50% b= % positive at dilution above 50% Production of Vaccines The harvested virus was inactivated refers to Yasumoto et al.
with minor modifications.
Unlike what did Yasumoto in common carp (Cyprinus carpi.
where the KHV vaccines produced from KF-1 cell is inactivated with 0.
3% formalin and stored for 48 hours at a temperature of 24AC before use.
The vaccine in this study are inactivated with formalin 0.
1% of the KHV virus then filtered using a 450 nm millipore and directly used for the test.
Adjuvants was substances added to vaccines to stimulate the immune response.
Differences between CFA and IFA contained in the composition of the constituent material which was in 1 mL CFA consisted of 1 mg of Mycobacterium tuberculosis in the form of heat-killed/dried.
85 mL of paraffin oil.
15 mL mannide monooleate.
However M.
tuberculosis not contained in the IFA.
The comparison between either complete or incomplete adjuvant and vaccine solution were 0.
The composition of adjuvant and vaccine was obtained from Agar Gel Precipitation Test (AGPT) which carried out previously.
Vaccination Vaccination was performed by the method of intramuscularly injection with a volume of 0.
1 mL/fish.
The experimental design was Completely Randomized Design with five treatments and four replications as follows: treatment A: vaccines.
treatment B:
vaccine Complete FreundAos Adjuvant.
treatment C:
vaccine Incomplete FreundAos Adjuvant.
K : positive control .
njected with PBS, tested challenge.
K-:
negative control .
njected with PBS, challenged not Fish were reared in plastic container sized 60 cm x 70 cm x 40 cm with stocking density of 15 fish Water temperature was range at 24AC25AC and fed with a pellet twice a day at satiation.
The fourth replications in each treatment used for blood and serum sampling.
Challenge Test Challenge test was performed on day 21 after vaccination and maintenance carried out for 14 days post challenge test.
The fish were injected intramuscularly with 0.
1 mL of virus inucula/fish.
Virus was diluted up to 100 times .
of TCID50/mL have been done previously.
TCID50 already used to obtain Lethal Dose 50 (LD.
from the KochAos postulates.
Koch postulate test was done with serial dilutions using TCID50 dose without dilution.
TCID50 dilution 10 times.
TCID50 dilution 100 times.
TCID50 dilution 1,000 times and TCID50 dilution 10,000 times.
KochAos postulates test showed that the LD50 was obtained on TCID50 dilution 100 times.
Dose of 100 times of virus dilution then was used for a challenge test by injecting 1 mL each fish.
Measurement of Immunological Parameters Measurement parameters of the immunological system consists of antibody titer by ELISA, hematocrit, and lysozyme activity.
Indonesian Aquaculture Journal, 11 .
, 2016, 41-47 Preparation of antigen for the ELISA test conducted prior to the KHV virus purification process according to Ronen et al.
Purified protein of KHV antigen was measured by the method of Bradford.
Antigen was coated 10 ug/mL in each well and incubated at 4AC overnight.
Directly plate was blocked using 200 AAL of PBS-BSA 1% and incubated at 22AC for one hour.
Plate was washed three times with 400 AAL of PBS-T.
Serum samples were then added to each well of 200 AAL (Dupl.
and incubated at a temperature of 22AC for three hours.
Plate was washed three times with 400 AAL of PBS-T.
Koi carp (Cyprinus carpi.
IgM monoclonal antibody (AQUATIC Diagnostics Ltd.
added about 100 AAL in each well and incubated at 22AC for one hour.
Plate was washed three times with 400 AAL of PBS-T.
Anti-mouse IgG-peroxidase antibody produced in rabbit (SIGMA-ALDRICH) was added to each well of 100 AAL and incubated at 22AC for one Plate was washed three times with 400 AAL of PBS-T.
One-Step Ultra TMB-ELISA was further added to each well of 100 AAL and let stand for 10 minutes.
The reaction was stopped by adding 50 AAL H2SO42M and do the reading optical density (OD) at 450 nm.
The cut of value (CV) in this test was obtained by the CV = Mean negative control .
x standard Hematocrit measurement is done by comparing a part of blood that settles .
to all parts of the blood contained in the microhematocrit tube .
, hematocrit levels expressed as % volume solid blood cells were calculated by using the equation of:
He A x 100% Measurement of lysozyme was conducted according the method of Kafilzadeh .
which 10 AAL of plasma added into 190 AAL liquid suspension of Micrococcus lysodeicticus (Sigm.
at 25AC.
The lysozyme activity can be formulated as follows:
Lysozyme activity (UI/mL/minut.
= [(OD 30s Ae OD 30.
x 1,.
) 1,000 was conversion of the absorbance (OD) into international units (UI), t was time .
, p was plasma volume .
L).
30s is optical density readings on 30 seconds.
30m is optical density readings on 30 minutes Survival Rate (SR) SR (%) A x 100% Nt was the number of live koi at the end of the observation.
No was the number of koi in the initial Relative Percent Survival (RPS) E % fish mortality of vaccinatedE
E x 100
RPS A EE1 A
% Fish mortality of control EE Statistical Analysis Results are presented as Means A SD .
tandard deviation of mean.
and homogenic data was perform before analysis.
The SPSS (Version, 20.
programs were used for the statistical analyses.
Oneway analysis of variance (One-way ANOVA) was used to determine whether there were any significant differences between treatments.
If so, all treatments were further tested by Duncan Multiple Range Test (DMRT).
All test were performed at the 95% confidence interval (P C 0.
RESULTS AND DISCUSSIONS
Survival Rate Survival of fish among treatments were significantly different (P<0.
All fish in K- treatment .
egative contro.
survived until the end of the study.
This was in contrast with the treatment of K .
ositive contro.
where at the end of the study fish alive only Fish in treatment A .
B .
accine CFA), and C .
accine IFA) successively survival of 88%, 82.
22%, and 60.
The highest survival was achieved by treatment B.
Value of survival and relative survival were shown in Table 1.
Relative Percent Survival While relative survival of both treatment A and C are not significantly different, but A and C significantly different with B (P<0.
The highest relative survival was achieved by treatment B, its the same thing with the achievements of the percentage of The survival of control fish were significantly different (P<0.
compared with other treatments (Table .
It indicates that vaccination improved survival of fish.
All fish in the negative control alive from the beginning to the end of the study, and unlike the case with the positive control, in which the remaining fish was only 15.
55 A 3.
The highest survival was achieved by treatment vaccination with the addition of Complete FreundAos Adjuvant/CFA .
reatment B), followed by vaccine treatment .
reatment A) and then treated with additional vaccinations In- Potency and efficacy test of a vaccine in addition with adjuvant .
(Lili Sholicha.
Table 1.
Survival rate (SR) and relative percent survival (RPS) of fish during the study period of adjuvant and formalin inactivated vaccine against KHV in koi Treatments Parameter 55 A 3.
00 A 0.
00 e 68.
88 A 3.
84 c 82.
22 A 3.
84 d 60.
00 A 6.
SR (%)
RPS (%)
Description:
100 A 0.
15 A 4.
53 c 78.
94 A 4.
55 d 52.
63 A 7.
no vaccined, challanged (K ), no vaccined, no challanged (K-).
KHV vaccines (A).
KHV vaccine with the addition of Complete FreundAos Adjuvant (B).
KHV vaccine with the addition of Incomplete FreundAos Adjuvant (C).
Different superscript in the same row indicate significantly different (P<0.
Data is expressed as Mean A SD complete FreundAos Adjuvant / IFA .
reatment C).
The addition of the adjuvant vaccine was found to further increase the survival of fish than just vaccine only.
is shown that B was significantly different (P<0.
with A and in accordance with the opinion of Kuby .
, that the adjuvant is a substance when mixed with antigen then injected together will work to improve the immunogenicity of the antigen.
vaccination unless treatment C .
63 A 7.
89%).
This is in line with Amend .
that for effective protection RPS suggested value of more than 60%.
Based on the results of this study it is not advisable to use C treatment because C does not meet the minimum limit the effectiveness of vaccine protection.
While the effectiveness of the vaccine protection can also be seen from the relative survival in Table 1.
The highest survival was achieved by treatment B followed treatment A and C.
The treatments A was significantly different (P<0.
with C.
RPS were obtained in the treatment of vaccination meet the range for effective protection in the process of Vaccination aims to induce long-term immunity by stimulating specific components of the immune response is an antibody by inducing the formation of specific antibody.
Figure 1 shows absorbance of vaccinated koi higher than the control.
Before vaccination antibody titers tend to be similar and not significantly different (P>0.
among treatments.
The ELISA Assay OD .
Days post vaccination .
Figure 1.
ELISA absorbances during the study period of adjuvant and formalin inactivated vaccine against KHV in koi.
This test had been carried out using a monoclonal antibody.
Description: no vaccined, challanged (K ), no vaccined, no challanged (K-), vaccines (A).
Complete FreundAos Adjuvant vaccined (B).
Incomplete FreundAos Adjuvant vaccined (C), cut off value (CV), vaccination (V), challenge test (T) Indonesian Aquaculture Journal, 11 .
, 2016, 41-47 cut off value (CV) or borderline positive value indicates the formation of protective antibodies against KHV obtained in this study at 0.
377 nm.
Absorbance values of K and K- during the study were below the CV, indicates that no protective antibodies against KHV.
Positive anti-KHV antibodies formed in all treatments vaccination from 14 to 35 dpv.
Anti-KHV antibodies begin to form at 7 dpv namely in treatment A and C as indicated by intersect to the line CV (Figure .
While on treatment B had positive antibodies directly even reach the top of the formation of antibodies.
This is presumably due to the effect of the vaccine and the addition of adjuvants in vaccines.
Antibody formation is influenced by several factors such as temperature, dose of the vaccine, vaccine administration, the age, and weight of fish as well as the nature of the antigen (Ellis, 1.
The use of adjuvants capable of increasing the titer two times higher than without adjuvant (De Jong et al.
, 2.
In addition, adjuvants are also able to create a balance of humoral antibody response (Hunter, 2.
It shows that the inserted antigen be antigenic as capable of inducing an immune response to an increase in the value of antibody titers at vaccination Hematocrit Level Hematocrit level can be seen in Figure 2.
Prior to vaccination and one week after vaccination there was no significant difference among treatments (P>0.
At 14 dpv, there are significant differences (P<0.
between K .
K-.
C with A and B.
The highest hematocrit levels achieved on day 21 dpv in treatment B and significantly different (P<0.
with other treatments.
At 28 dpv and 35 dpv hematocrit levels decreased but treatment B was the highest and significantly different with other treatments (P<0.
Hematocrit is the percentage ratio between the solid red blood cells and plasma in the blood.
Generally hematocrit before vaccination and one week after vaccination tend to be low and stable (Figure .
Entering the second week .
hematocrit of treatment A and B slightly higher and significantly different (P<0.
with the control and C.
While the hematocrit reached the highest peak in the third week .
is achieved by B.
In normal conditions, hematocrit levels of carp ranged from 32% to 43.
8% (Radu.
Shortly after the challenge test, hematocrit levels increased and then begin to decline until the end of the maintenance period.
Decrease in hematocrit levels after challenge test showed that KHV infection that attacks fish is quite serious.
Factors Hematocrit (%) Figure 2.
Day post vaccination .
Hematocrit levels during the study period of adjuvant and formalin inactivated vaccine against KHV in koi.
Description: no vaccined, challanged (K ), no vaccined, no challanged (K-), vaccines (A).
Complete FreundAos Adjuvant vaccined (B).
Incomplete FreundAos Adjuvant vaccined (C), vaccination (V), challenge test (T).
Different superscript in the same group time indicate significantly different (P<0.
Data are expressed as Mean A SD Potency and efficacy test of a vaccine in addition with adjuvant .
(Lili Sholicha.
Lysozym activity (UI/mL/minut.
Day post vaccination .
Figure 3.
The activity of lysozyme during the study period of adjuvant and formalin inactivated vaccine against KHV in koi.
Description: no vaccined, challanged (K ), no vaccined, no challanged (K-), vaccines (A).
Complete FreundAos Adjuvant vaccined (B) Incomplete FreundAos Adjuvant vaccined (C), vaccination (V), challenge test (T).
Different superscript in the same group time indicate significantly different (P<0.
Data are expressed as Mean A SD causing the decrease in hematocrit allegedly associated with a decrease in hemoglobin due KHV infection.
This decrease was associated with hemorrhage in the base of the fin and bleeding in the brain.
Lysozyme Activity Figure 3 shows lysozyme activity of fish.
Before vaccination, the amount of lysozyme activity was not significantly different among treatments (P>0.
Lysozyme value of K and K- is significantly different (P<0.
with A and C and also significantly different with the treatment B on the 7 dpv.
At 14 dpv treatment K and K- significantly different compared 21 dpv the activity of lysozyme reached the highest peak in treatment B and significantly different from other A week after the challenge test .
each lysozyme activity decreased and continue to decrease till 35 dpv.
Treatment B still shows higher but not significantly different with treatment A (P>0.
and significantly different (P<0.
with K .
K-, and C.
Lysozyme is an important component in the defence system against pathogens.
Lysozyme in fish can be detected from the serum, mucus, plasma, and organs such as gills and liver.
Figure 3 shows the activity of lysozyme in general tends to increase after vaccination and tends to decrease after challenge test.
Vaccination treatment can increase the activity of lysozyme and significantly different (P<0.
with the Increased activity of this enzyme is also obtained in tilapia injected ECP Pseudomonas fluorescens (Attia et al.
, 2.
According Saurabh & Sahoo .
lysozyme is a distributed hydrolase, and plays an important role in the biological defense system.
This enzyme has antiviral, antibacterial and anti-inflammatory properties.
In addition, increase lysozyme activity closely associated with humoral factors that can increase phagocytic activity in fish (Veersamy et , 2.
On the positive control (K ) is very clearly visible decrease in the activity of lysozyme after challenge test.
Lysozyme in fish is an indicator of nonspecific immune response to the invasion of antigens.
Lysozyme is the first layer of defense mechanism that is very important for fish to fight pathogens (Saurabh & Sahoo, 2.
Lysozyme can increase phagocytic activity is as opsonin or directly activate neutrophils and macrophages (Bhagwat et al.
, 2.
Indonesian Aquaculture Journal, 11 .
, 2016, 41-47
CONCLUSION
The application of inactivated vaccine with the addition of Complete FreundAos Adjuvant resulted the highest survival and enhancement of the immune response in koi (C.
against KHV infection.
ACKNOWLEDGMENT
Thanks to the Ministry of Marine Affairs and Fisheries Republic of Indonesia for providing partial funding of the study, thanks to Research and Development Institute for Ornamental Fish Culture.
Depok for supporting research, and also thanks to Research Station for Fish Disease Control for allowing to work in the laboratory.
REFERENCES